對準埋地管道電化學腐蝕的三個進程，聚氨酯保溫鋼管的防腐辦法也從克制其間某一進程下手。故防腐涂層與陰極維護相結合才是表本兼治的辦法，經濟而有用。因為在輸出電流進程中遭受損壞，鎂合金陽極的描繪運用年限更棒與管道的運用年限相匹配，既不發作鋪張也不多添加維護費用。
In view of the three processes of electrochemical corrosion of buried pipelines, the anticorrosion method of polyurethane insulated steel pipes should also start from restraining one of them. Therefore, the combination of anti-corrosion coating and cathode maintenance is an economical and useful method. Because it is damaged in the process of output current, the service life of the magnesium alloy anode is best matched with the service life of the pipeline, which is neither extravagant nor expensive.
不一樣的防腐辦法有不一樣的防腐質量和費用，應根據被維護聚氨酯保溫鋼管的不一樣壓力、不一樣用處及其所在的不一樣環境和運送的不一樣燃氣，歸納全部地思考防腐辦法和防腐費用。當扁平量添加到50毫米時，裂縫逐步添加到邊部全管段，試驗成果，管徑1%的扁平量時發作"發狀"裂縫，當扁平量為6-9%的場合，沙漿涂層開端崩裂，到達管徑30%時脫落。這在施工中是決不允許發作的。
Different anti-corrosion methods have different anticorrosion quality and cost. The anticorrosion method and cost should be considered according to the different pressure, different use, different environment and different gas transported. When the flattening amount is 50 mm, the cracks are gradually added to the whole pipe section at the edge. According to the test results, when the flattening amount is 1% of the pipe diameter, the "hairy" cracks occur. When the flattening amount is 6-9%, the mortar coating begins to crack and falls off when reaching 30% of the pipe diameter. This is not allowed to happen in construction.
聚氨酯保溫鋼管在受外壓變形變扁平常，砂漿會發作"發狀"裂縫，但要砂漿從管壁上剝離卻是十分艱難的，在口徑DN800毫米壁厚為7.1毫米的鋼管上，截取一米長的管段，涂襯11毫米厚的砂漿涂層，當扁平量7-8毫米時，可以看到"發狀"裂縫的呈現。據測定，在DN1100管子上，更小扁平量為15毫米，DN1800管上為21毫米。由此可見，管徑的增大，發作裂縫的扁平量也隨之增大。水泥沙漿面料有以下幾個顯著的長處：避免管道內壁腐蝕銹垢的發作，使管道長期保持杰出的輸水狀況，摩阻系數小。
It is common for polyurethane thermal insulation steel pipe to deform and flatten under external pressure. However, it is very difficult to peel the mortar from the pipe wall. On the steel pipe with diameter of DN800 mm and wall thickness of 7.1 mm, one meter long pipe section is cut off and coated with 11 mm thick mortar coating. When the flattening amount is 7-8 mm, hairy cracks can be seen. According to the measurement, the minimum flattening is 15 mm on the pipe of DN 100 and 21 mm on the pipe of DN 1800. It can be seen that with the increase of pipe diameter, the flattening amount of cracks will also increase. The cement mortar fabric has the following obvious advantages: it can avoid the corrosion and scale on the inner wall of the pipeline, keep the pipeline in excellent water delivery condition for a long time, and the friction coefficient is small.
水泥砂漿的施工有兩種辦法。一是地上離心法。首要適同于DN400口徑以下的管道內襯施工。而是地下噴涂法，首要適用于DN700口徑以上的管道在地下防腐施工。因為面料涂層的阻隔，水體不與金屬管道觸摸，包管了水質。
There are two ways to construct cement mortar. One is centrifugation on the ground. It is suitable for lining construction of pipes with diameter below dn400. It is the underground spraying method, which is mainly applicable to the underground anti-corrosion construction of pipes with diameter above DN700. Because of the barrier of the fabric coating, the water does not touch the metal pipe, which guarantees the water quality.
管道內壁由水泥砂漿的防腐，避免了腐蝕穿孔，延長了管道運用壽命，水泥沙漿涂層的資料選材便利，施工周期短，防腐作用好，下降管道工程的本錢。鑒于水泥砂漿具有上述長處，其防腐的功用和經濟性，被越來越多的國內外的工程技術部門認可，國內大中城市都推行運用水泥砂漿作為給水金屬管道內防腐的首要受點。也為此擬定了水泥砂漿面料的標準和質量標準。
The inner wall of the pipeline is anticorrosive by cement mortar, which avoids the corrosion perforation and prolongs the service life of the pipeline. The material selection of the cement mortar coating is convenient, the construction period is short, the anti-corrosion effect is good, and the cost of the pipeline project is reduced. In view of the above advantages of cement mortar, its anti-corrosion function and economy are recognized by more and more engineering and technical departments at home and abroad. Domestic large and medium-sized cities promote the use of cement mortar as the primary receiving point of internal corrosion protection of water supply metal pipes. The state has also formulated the standard and quality standard of cement mortar fabric.
With the brief summary of polyurethane insulated steel pipe manufacturers, we hope to help our customers. If you have any questions or seek help, please click our website: http://www.zy365.cc Or call consultation, we will try our best to solve it for you
